How to maintain the fuel system of mixer truck?

1.及时加油

1. Refuel in time

在小型自动上料搅拌车的操作过程中，操作员应始终注意燃油量。 当燃油表上显示的燃油量接近“ 0”时，请确保及时补充燃油。 不要等到燃料用完后再添加。 这样的后果不仅导致柴油机在没有燃油后失速，而且导致空气进入燃油系统。 空气进入燃油系统后，不仅浪费了燃油，而且排放起来更加麻烦。

During the operation of small automatic loading mixer, the operator should always pay attention to the amount of fuel. When the fuel quantity displayed on the fuel gauge is close to "0", please make sure to replenish the fuel in time. Don't wait until you run out of fuel. This result not only causes the diesel engine to stall without fuel, but also causes air to enter the fuel system. After the air enters the fuel system, it not only wastes fuel, but also makes it more troublesome to discharge.

2.注意避免燃油系统堵塞

2. Pay attention to avoid fuel system blockage

众所周知，自动上料搅拌车的工作环境有时很特殊，很容易造成燃油系统堵塞。 一旦燃油系统堵塞，将影响机器的正常运行。 因此，请及时检查以确保燃油管道通畅。

As we all know, the working environment of automatic loading mixer is sometimes very special, which is easy to cause blockage of fuel system. Once the fuel system is blocked, the normal operation of the machine will be affected. Therefore, please check in time to ensure that the fuel pipe is unobstructed.

3.注意检查燃油系统的密封性

3. Check the tightness of the fuel system

在小型混凝土搅拌机上工作时，如果发现排气管冒出黑烟或发动机难以启动，则可能是由于漏气造成的，因此请注意检查燃油系统的密封性。

When working on a small concrete mixer, if it is found that the exhaust pipe emits black smoke or the engine is difficult to start, it may be caused by air leakage. Therefore, please pay attention to check the tightness of the fuel system.

4.保持燃油清洁

4. Keep the fuel clean

大约50％的燃油系统故障是由不干净的燃油引起的。 对于汽油发动机，大多数是由燃料中的水混合引起的。 汽油中的水也会腐蚀并损坏燃料供应系统的组件。

Approximately 50% of fuel system failures are caused by dirty fuel. For gasoline engines, most of them are caused by the mixing of water in the fuel. Water in gasoline can also corrode and damage components of the fuel supply system.

5.燃料选择至关重要

5. Fuel selection is crucial

建议选择适合自动上料搅拌车的高质量燃料。 劣质燃料的过滤，污泥，杂质和水分很差，这些杂质会长时间积累并沉淀下来，这很容易堵塞燃料泵滤清器，燃料管和燃料喷射器。

It is recommended to select high-quality fuel suitable for automatic feeding mixer truck. The filtration of inferior fuel, sludge, impurities and moisture are very poor. These impurities accumulate and settle down for a long time, which is easy to block the fuel pump filter, fuel pipe and fuel injector.

以上就是为大家介绍的有全自动上料搅拌车的详细介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以的态度,为您提供服务http://www.shanqijituan.com/

The above is a detailed introduction to the automatic feeding mixer. I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service http://www.shanqijituan.com/