Precautions to prevent blocking of concrete mixer truck:

1、混凝土上料搅拌车冬期施工时，一定要做到：开机前检查是否出现结冰情况；下班时认真排除拌筒内及供水系统内残存积水，关闭水泵的开关，将控制手柄置于“停止"位置。

1. During the winter construction of concrete loading mixer truck, it is necessary to check whether there is ice before starting up; When off duty, carefully remove the residual water in the mixing drum and the water supply system, turn off the switch of the water pump, and put the control handle in the "stop" position.

2、混凝土上料搅拌车在卸料的时候，如果发现水分蒸发，塌落度偏低不能满足用户需求时，可适当向筒内加水，然后以10-14r/min的速度旋转30转后再卸料，使混凝士充分搅拌。

2. When the concrete loading mixer truck is unloading, if it is found that the water evaporates and the slump is low, which can not meet the needs of users, it can add water to the cylinder appropriately, and then rotate at the speed of 10-14r / min for 30 revolutions before unloading, so as to fully mix the concrete..

3、混凝土上料搅拌车在空载运行的过程中，搅拌筒不得停转以免颤动时造成滚道和托轮局部磕碰，导致滚道和托轮的不正常损坏。

3. During the no-load operation of the concrete loading mixer, the mixing drum shall not stop, so as to avoid local collision between the raceway and the supporting wheel in case of vibration, resulting in abnormal damage to the raceway and the supporting wheel.

4、混凝土上料搅拌车水箱的水量要经常加满，作为备用。水箱加水前，需要打开放气阀把箱内空气放掉；冲洗时打开气阀，冲洗完毕或者停用的时候应将水罐内气体放掉。冬季停放的时候，水箱和供水系统里，不应该有多余的水，防止冻裂，水箱仅在供水时加压自动，混凝土上料搅拌车使用方法不要带着加压水箱在公路上行驶。

4. The water volume of the water tank of the concrete loading mixer truck shall be frequently filled up for standby. Before adding water to the water tank, open the vent valve to release the air in the tank; Open the air valve during flushing, and discharge the gas in the water tank after flushing or shutdown. When parking in winter, there should be no excess water in the water tank and water supply system to prevent frost cracking. The water tank is pressurized automatically only during water supply. The use method of concrete loading mixer truck should not drive on the road with pressurized water tank.

以上就是为大家介绍的有关自进料混凝土搅拌车的详细介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以的态度,为您提供服务http://www.cnzkjf.cn

The above is the detailed introduction of self feeding concrete mixer, which I hope will be helpful to you If you have any questions, please contact us We will provide you with professional service http://www.cnzkjf.cn