The use and maintenance of self feeding mixer trucks are closely related, and it is necessary to know how to use them cleverly to save a lot of unnecessary trouble. Next, let's take a look at the precautions when driving. The deeper our knowledge, the easier it will be to use and maintain the self feeding mixer truck.

1、自上料搅拌车作业设备连续工作时刻不该超越8h。运送混凝土的容量，质量及塌落度应契合混凝土行业标准和要求。

1. The continuous working time of the self feeding mixing truck operation equipment should not exceed 8 hours. The capacity, quality, and slump of transported concrete should comply with the standards and requirements of the concrete industry.

2、自上料搅拌车水箱的水量要经常加满，以备急用。水箱加水前，有必要翻开放气阀把箱内空气放掉；冲刷时翻开气阀，冲刷完毕或许停用时应将水罐内气体放掉。冬天停放时，水箱和供水体系里，不得有剩下水，避免冻裂。注意：水箱仅在供水时加压,不要带着加压水箱在公路上行进。

2. The water tank of the self feeding mixer truck should be frequently filled up for emergency use. Before adding water to the water tank, it is necessary to open the air valve to release the air inside the tank; When flushing, open the air valve. After flushing, or when not in use, the gas in the water tank should be discharged. When parking in winter, there should be no residual water in the water tank and water supply system to avoid freezing and cracking. Attention: The water tank should only be pressurized during water supply, and do not carry the pressurized water tank on the road.

3、自上料搅拌车在混凝土运送过程中罐体制止停转，避免形成混凝土的凝聚，停转重启时会形成对液压体系、减速机的冲击，致使液压泵和马达的损坏。

3. During the concrete transportation process, the self feeding mixer truck stops the tank from rotating to avoid the formation of concrete condensation. When stopped and restarted, it will cause an impact on the hydraulic system and reducer, causing damage to the hydraulic pump and motor.

4、满载混凝土正转，如要回转，有必要操作手柄使正转停稳后，再操作手柄回转。禁止正转过程中操作手柄使其回转。

4. Full load concrete is rotating forward. If you want to rotate, it is necessary to operate the handle to stop the forward rotation and then rotate the handle. Prohibit operating the handle to rotate during forward rotation.

5、自上料搅拌车卸料时，如发现水分蒸腾，塌落度偏低不能满意用户要求时，可适当向筒内加水，然后以10—14r/min的速度旋转30转后卸料，使混凝土充分拌和。

5. When unloading from the self loading mixer truck, if water transpiration and low slump are found to be unsatisfactory to the user's requirements, water can be added to the drum appropriately, and then rotated at a speed of 10-14 r/min for 30 revolutions before unloading to fully mix the concrete.

6、拌和车在空载运转过程中，拌和筒不得停转避免波动时形成滚道和托轮部分磕碰，致使托轮和滚道的反常损坏。

6. During the no-load operation of the mixing truck, the mixing cylinder must not stop to avoid the formation of collisions between the roller and the supporting roller during fluctuations, resulting in abnormal damage to the supporting roller and the roller.

自上料搅拌车在公路上行驶时，加长溜槽有必要放置在卸料溜槽支架上并用挂钩挂牢，不允许挂在主排料溜槽上运转；主排料溜槽要旋转到固定方位，拉下定位手柄，用锁紧手柄将绷簧变幅机构锁止，避免由于不固定而摇摆，形成伤人事端和影响其它车辆运转能

When the self loading mixer truck is driving on the highway, it is necessary to place the extended chute on the unloading chute bracket and hang it firmly with a hook. It is not allowed to hang it on the main discharge chute for operation; The main discharge chute should be rotated to a fixed position, the positioning handle should be pulled down, and the tension spring luffing mechanism should be locked with the locking handle to avoid swinging due to lack of fixation, causing injury and affecting the operation of other vehicles

自上料搅拌车

Self loading mixer truck

本文由小型混凝土自动搅拌车友情奉献.更多有关的知识请点击:http://www.cnzkjf.cn 真诚的态度.为您提供为的服务.更多有关的知识我们将会陆续向大家奉献.敬请期待.

This article is dedicated by a small concrete automatic mixer truck. For more information, please click on: http://www.cnzkjf.cn Sincere attitude. We will provide you with comprehensive services. We will gradually contribute more relevant knowledge to everyone. Stay tuned