Zhongkejufeng small concrete mixer is a construction vehicle used to transport concrete; because of its shape, it is usually called snail. In the actual operation of the equipment, the handling of the mixer is also an important part. Therefore, it is necessary to test the quality of oil products in the process of use, so how to operate?

　　1.在水平面上进行混合器，拧紧手刹。

　　1. Mix the mixer on the horizontal surface and tighten the handbrake.

　　2.让发动机空转几分钟。

　　2. Allow the engine to idle for a few minutes.

　　3.按下刹车踏板，将变速杆转到倒车、前进等方向，在每个档位上停留几秒钟，将变矩器和所有换挡执行机构注满液压油，将变速杆转到停车位置。

　　3. Press the brake pedal, turn the transmission lever to the reverse, forward and other directions, stop at each gear for a few seconds, fill the torque converter and all shift actuators with hydraulic oil, and finally turn the transmission lever to the parking position.

　　4.将自动变速器的油尺从油管上取下，将清洗过的油尺插入油管中，拔出后检查油尺上的油位。

　　4. Remove the dipstick of automatic transmission from the oil pipe, insert the cleaned dipstick into the oil pipe, and check the oil level on the dipstick after pulling out.

　　检查自装式搅拌机或其缺陷前，请先检查传动油位和油质。把变速杆放在P的位置和操作引擎少几分钟空转时,石油达到正常的工作温度,它是必要的车辆停在水平表面,以确保微分之间的油位和节流阀。传输通常是的。

　　Check the transmission oil level and quality before checking the self-contained mixer or eliminating its defects. Put the gear lever in P position and operate the engine at idle for at least a few minutes when the oil reaches normal operating temperature, it is necessary for the vehicle to stop on a horizontal surface to ensure differential between the oil level and the throttle valve. Transmission is usually secure.

　　1.进水系统可根据称重设置自动进水。

　　1. The water inlet system can automatically feed water according to the weighing setting.

　　2.进料混合滚筒的旋转是由液压马达通过专用行星齿轮驱动的。行星齿轮的输出轴可以在恒定的角度上进行振动，以满足恶劣路况下进料混合鼓的跳动。

　　2. The rotation of feed mixing drum is driven by hydraulic motor through special planetary gear. The output shaft of the planetary gear can vibrate at a constant angle to meet the beating of the feed mixing drum in bad road conditions.

　　3.双螺旋叶片安装在混凝土搅拌车搅拌筒内壁上。前送与混凝土混合，后旋转混凝土在螺旋叶片的向下压力下从出口排出。

　　3. The double spiral blade is installed on the inner wall of the mixing drum of the concrete mixer. The forward feed is mixed with the concrete, and the backward rotating concrete is discharged from the outlet under the downward pressure of the spiral blade.

　　4.供应干料，并按计划比例自动供应斗臂、动臂油缸、计量斗。

　　4. Supply dry materials and automatically supply the bucket arm, boom cylinder and metering bucket according to the planned proportion.

　　5.液压系统采用恒功率变排量活塞泵，减少发动机功率损失。

　　5. The hydraulic system adopts constant power variable displacement piston pump to reduce engine power loss.

　　6.行走系统由发动机从变矩器和前后传动轴驱动到前后轴。液力变矩器的应用减少了对发动机的影响，延长了发动机的使用寿命。

　　6. The traveling system is driven by the engine from the torque converter and front and rear transmission shafts to the front and rear shafts. The application of the hydraulic torque converter reduces the influence on the engine and prolongs the service life of the engine.

　　中科聚峰小型混凝土搅拌车在运输过程中始终保持搅拌筒转动，以保证混凝土不凝固。混凝土交付后，搅拌桶的内部通常用水冲洗，以防止硬化混凝土占用空间，并减少搅拌桶的体积。

　　In order to ensure that the concrete does not set, the mixing drum of zhongkejufeng small concrete mixer always keeps rotating during transportation. After the concrete is delivered, the inside of the drum is usually washed with water to prevent the hardened concrete from taking up space and to reduce the volume of the drum.