Small concrete mixer is a very good vehicle for transporting and mixing concrete. Because of the strong adhesion of concrete and the fact that the mixer truck often transports concrete of various properties, when the concrete is transported from the truck, there will be residues on the truck. How to clean up the concrete residue on zhongkejufeng mixer? Here are two methods:

　　方法一:

　　Method 1:

　　1.准备应急驱动软管，关闭小型混凝土搅拌机，取下液压马达上的高压管接头。

　　1. Prepare the emergency drive hose, close the small concrete mixer, and remove the high-pressure pipe joint on the hydraulic motor.

　　2.关闭救援车，取下其液压马达高压油管，将应急驱动软管与故障车辆相应接头连接。

　　2. Close the rescue vehicle, remove the high-pressure oil pipe of its hydraulic motor, and connect the emergency drive hose with the corresponding joint of the failed vehicle.

　　3.启动救援车，将其控制手柄移动到卸料位置，故障车辆内的混凝土将被卸料。

　　3. Start the rescue vehicle, move its control handle to the unloading position, and the concrete in the failed vehicle will be unloaded.

　　4.紧急驱动完成后，拆卸驱动软管，恢复两辆车的原始状态。

　　4. After the emergency drive is completed, remove the drive hose and restore the original state of the two vehicles.

　　方法2:

　　Method 2:

　　在托轮与滚道之间放置木楔，控制搅拌筒转动;关掉引擎,除去液压马达,高压油管和小型混凝土搅拌机的搅拌缸可以自由旋转,控制搅拌筒的转动,使维修孔底部,然后打开维修孔清理混凝土缸。当混凝土被排出时，它将恢复到原来的状态。

　　Place a wooden wedge between the supporting wheel and the raceway to control the rotation of the mixing drum; turn off the engine, remove the hydraulic motor, the high-pressure oil pipe and the mixing cylinder of the small concrete mixer can rotate freely, control the rotation of the mixing drum, make the bottom of the maintenance hole, and then open the maintenance hole to clean the concrete cylinder. When the concrete is discharged, it will return to its original state.

　　这两种方法均可用于小型混凝土搅拌车上混凝土杂物的，无任何残留。搅拌车应在清洗前停止。搅拌车清理干净后，可以运送下一堆混凝土进行搅拌，防止残留的旧混凝土与新混凝土混合。

　　These two methods can be used for the removal of concrete debris on the small concrete mixer without any residue. The mixer shall be stopped before cleaning. After the mixer is cleaned, the next pile of concrete can be transported for mixing to prevent the residual old concrete from mixing with the new concrete.

　　以上是中科聚峰厂家为大家介绍的相关内容，想要了解更多内容，欢迎访问网站：http://www.cnzkjf.cnThe above is the relevant content introduced by Zhongke Jufeng factory. To learn more, please visit the website: http://www.cnzkjf.cn