01 oil change

起动发动机，在怠速情况下（保养完毕后发动机严禁立即高速运转），观察滤清器和放油螺塞是否有泄漏。停机等待5到10分钟后，抽出机油尺检查机油油面，直机油油面达到正常水平，即机油标尺上下刻度之间。

Start the engine and observe whether the filter and drain plug leak at idle speed (it is strictly forbidden to run the engine at high speed immediately after maintenance). After shutdown and waiting for 5 to 10 minutes, pull out the oil dipstick to check the oil level until the oil level reaches the normal level, that is, between the upper and lower scales of the oil dipstick.

02燃油滤芯保养

02 fuel filter element maintenance

保养周期：新搅拌车行驶2000km—3000km或2个月内更换燃油滤芯，以后每行驶20000km或1年（先到为准）进行一次定期保养。根据各地区环境差异,选用适当牌号的正规柴油。

Maintenance cycle: the fuel filter element shall be replaced within 2 months after the new mixer is driven for 2000km-3000km, and regular maintenance shall be carried out every 20000km or 1 year (whichever comes first). According to the environmental differences of various regions, the proper brand of regular diesel oil shall be selected.

03空气滤芯保养

03 air filter element maintenance

1、空气滤芯每周保养一次，每行驶10000或6个月（先到为准）更换滤芯。

1. The air filter element shall be maintained once a week, and the filter element shall be replaced every 10000 km or 6 months (whichever comes first).

2、将驾驶室举升，注意在举升过程中注意举升油缸上的支撑杆的位置，在举升完成后确认锁扣是否扣到位。

2. First lift the cab, pay attention to the maximum position of the support rod on the lifting cylinder during the lifting process, and confirm whether the safety latch is buckled in place after the lifting is completed.

03

03

3、拆开空气滤芯滤清器盖子，用活动扳手拧松空气滤芯固定螺母，将外芯取出。

3. Remove the cover of the air filter element, loosen the fixing nut of the air filter element with an adjustable wrench, and take out the outer core.

03

03

4、用抹布擦拭空气滤芯外壳的内壁，并用不大于0.4Mpa的压缩空气吹除滤芯上的灰尘，由内向外吹检查空滤器进气道内是否干净。

4. Wipe the inner wall of the air filter element shell with a rag, blow off the dust on the filter element with compressed air not greater than 0.4MPa, and blow it from inside to outside to check whether the air inlet of the air filter is clean.

5、吹完后，按与拆除滤芯相反的顺序重新安装滤芯，旋转180°，再拧紧螺母，检查各密封圈是否完好。

5. After blowing, reinstall the filter element in the reverse order of removing the filter element, rotate it 180 °, then tighten the nut and check whether each sealing ring is intact.

04冷却系统保养

04 cooling system maintenance

冷却液液更换：

Coolant change:

1、冷却液型号：-45#，整车加注约40升。

1. Coolant model: -45#, about 40L for the whole vehicle.

2、每行驶60000或2年更换一次冷却液，以先到为准。

2. Change the coolant every 60000 km or 2 years, whichever comes first.

以上就是小型混凝土自动搅拌车http://www.cnzkjf.cn为大家介绍的内容，感谢您在百忙之中查看我公司的信息内容，如果您想要了解的更多，欢迎您来电进行咨询!

The above is a small automatic concrete mixer http://www.cnzkjf.cn Thank you for checking the information of our company in your busy schedule. If you want to know more, you are welcome to call for consultation!