As the saying goes, the self feeding concrete mixer is repaired in three parts and maintained in seven parts, and the usual maintenance is particularly important. This time, we will give you a detailed introduction from the pre departure maintenance of self feeding concrete mixer.

出车前：检查、发现问题并排除故障常规检查

Before departure: check, find problems and eliminate faults, and conduct routine inspection

自进料混凝土搅拌车怕在路上罐子不转，混凝土一般停罐不能超过2个小时，C40以上级别的混凝土在路上罐子就不能停。车子启动后，先让罐子低速旋转，围绕车检查轮胎胎面、胎压等，检查是否有石子、铁钉之类扎在胎里，及时清理干净。

The self feeding concrete mixer is most afraid of the tank not rotating on the road. Generally, the concrete tank cannot be stopped for more than 2 hours, and the tank of concrete above C40 cannot be stopped on the road. After starting the car, first let the jar rotate at a low speed, check the tire tread and tire pressure around the car, check whether there are stones and nails stuck in the tire, and clean them in time.

自进料混凝土搅拌车特别注意事项检查

Inspection for special precautions of self feeding concrete mixer

螺栓巡检：包括减速机与罐体连接螺栓、减速机底座固定螺栓、连接件螺栓以及U型螺栓等，在日常运行中一定要做到定期保养，新车出厂前检查是否松动，复紧周期为使用周，后续每月检查紧固一次，做到防患于未然。

Bolt patrol inspection: including the connecting bolts between the reducer and the tank body, the fixing bolts of the reducer base, connector bolts and U-shaped bolts. Regular maintenance must be carried out in daily operation. Check whether the new car is loose before leaving the factory. The first re tightening cycle is the first week of use, and then check and tighten once a month to prevent trouble.

自进料混凝土搅拌车润滑油更换包括减速机齿轮油、液压系统中的液压油、发动机机油等，一旦缺少就会对相关部件造成磨损，影响车子的整体性能。建议工作100小时更换，以后每1000小时更换一次（每年少更换1次 ）。

Lubricating oil replacement of self feeding concrete mixer includes gear oil of reducer, hydraulic oil in hydraulic system, engine oil, etc. in case of lack, it will cause wear to relevant parts and affect the overall performance of the vehicle. It is recommended to replace it after 100 hours of operation for the first time and every 1000 hours thereafter (at least once a year).

散热器滤芯更换散热器就等同于车子的呼吸系统，一旦“呼吸”不畅通，就会造成发动机过热从而引发爆缸等问题，所以日常工作中一定要定期检查，更换滤芯，可以和液压系统保养同时更换，真空表指针位于红色区域时更换滤芯，每年少要更换一次。

Replacing the radiator filter element is the same as the car's respiratory system. Once the "breathing" is not unblocked, the engine will overheat and cause cylinder explosion. Therefore, the filter element must be checked regularly in daily work. The filter element can be replaced simultaneously with the maintenance of the hydraulic system. When the pointer of the vacuum gauge is in the red area, the filter element shall be replaced at least once a year.

加注黄油传动轴、滚道、拖轮、主槽转轴、操纵杆等部件要保证每月加注一次黄油，减少关键部件磨损，从而延长使用寿命。

Grease the transmission shaft, raceway, tug, main slot shaft, control lever and other parts once a month to reduce the wear of key parts and prolong the service life.

以上内容就是关于自进料混凝土搅拌车http://www.cnzkjf.cn/的介绍，希望这些内容对大家有所帮助。如果您还有什么疑问,或者想要了解更多资讯欢迎咨询我们官网。我们将竭诚为您服务。

The above content is about the self feeding concrete mixer http://www.cnzkjf.cn/ I hope these contents will be helpful to you. If you have any questions or want more information, please consult our official website. We will serve you wholeheartedly.